Dongzi Li1
Wantao Fu
Xupeng Cao- 1Marine College of Science-Technology and Environment, Dalian Ocean University, Dalian, China
- 2Dalian Institute of Chemical Physics, Chinese Academy of Sciences, Dalian, China
- 3State Key Laboratory of Catalysis, Dalian Institute of Chemical Physics, Chinese Academy of Sciences, Dalian, China
- 4Dalian National Laboratory of Clean Energy, Division of Solar Energy, Dalian Institute of Chemical Physics, Chinese Academy of Sciences, Dalian, China
- 5Dalian Key Laboratory of Energy Biotechnology, Dalian Institute of Chemical Physics, Chinese Academy of Sciences, Dalian, China
Microalgae is a promising organism as the feedstock of the next generation biofuels, as well as high value nature products, such as astaxanthin, normally under certain stress cultivation conditions. With the clear industrialization targets, there have been two waves of microalgae R&D from the last century and showed obvious energy-driven trends. The overall R&D came into a valley now, however, the promising is still there. So here, from the industrialization point of view, the patent evolution concerning the microalgae for biofuels in the second wave were reviewed and summarized. These technology information will help the scientists to join together with industry to drive the next boost.
Introduction
Microalgae are found in both marine and freshwater environments and convert carbon dioxide to potential biofuels (carbohydrates, lipids), foods and high-value products, driven by solar energy, as well as are good organisms for bioremediation applications (Sheehan et al., 1998; Chisti, 2007; Hu et al., 2008; Mata et al., 2010; Wijffels and Barbosa, 2010; Chen et al., 2018; Khan et al., 2018; Shuba and Kifle, 2018). With the afraid of fossil fuel crisis, it’s officially considered as a solution at 1978 under the program funded by the US Department of Energy’s Office of Fuels Development, known as the Aquatic Species Program (or ASP), which main focus was the production of biodiesel from high lipid-content algae grown in ponds, utilizing waste CO2 from coal fire power plants (Sheehan et al., 1998). Over the nearly two decades (from 1978 to 1996), ASP stopped far from the industrialization of microalgae as fuels stocks, one reason for which was the high life-span cost comparing with the relative low price of the fuels. However, ASP promoted the R&D of microalgae from the collection and evaluation of thousand species, the science of manipulating the genes and metabolism, to the engineering of production systems. The detailed contributions of ASP was well-documented Sheehan et al. (1998).
While the oil price dramatically increased from the beginning of the twenty-first century, microalgae come back the visual field again with the support from governments, the industries and the venture capitals all over the world, but cooled down after 2015 till now, indicated by the takeover of Solazyme by TerraVia in US and retreat of ENN in China. The rise and fall of it was the result of multi factors, which was not only the affair of science and technology. As one of the key components of the innovation, the patent bridges the lab and the factory. Here, after the second wave of microalgae R&D, the patent evolution during the last 20 years were quickly reviewed for the reference to the next boost of microalgae industrialization.
The Analysis of Microalgae Biofuels Related Patents From Last 20 Years
Patents Collection and Refinement
The patents data used here were mainly from Patsnap® patent database and Derwent World Patents Index was used as an amendment. The keywords used for index were provided in Supplementary Data File. More than ten thousand patents were further refined, considering the fact that microalgae biofuels production is the process to convert solar energy to chemical energy by photosynthesis in a direct or indirect manner, the photosynthesis related information should be shown in the claims, such as autotrophic growth, or with light, etc.
Differing to normal research publications, the patent is a kind of legal documents and a collection of patent applications covering the same or similar technical content were defined as a family, which can help us to focus on the technical part of patents, other than the different legal status. After refine, 3,393 items from 730 families were extracted for the further analysis. To verify the coverage of the index, 11 patents from authors were used as a reference, which covers the strain screening and application to the downstream bio-refinery to biofuels, and all of them were included by above index.
The Patent Application Amount Change With Crude Oil Price
The aim of the development of biofuels is the makeup or replacement of traditional fossil fuels, especially the oil, for the reason of the final products of the biofuels. So the difference between the cost of biofuels to oil should be a driving force of the R&D development of microalgae.
The crude oil prices per barrel of West Texas Intermediate (WTI) with the adjustment for inflation using the headline CPI were collected from Macrotrends database1. For simplification, the average price of January of each were used to compared with the yearly patent application status. In Figure 1, the overall correlation of oil price to the number of patent application is about 0.86 before 2015 and 0.84 till now.
Figure 1. The patent application changes in last 30 years. The upper figure is the application in terms of single patent and patent family. The bottom figure is the application changes with the crude oil prices. The timeline in the middle marks some milestones for microalgae biofuel R&D development.
Although only a little changes in the correlation factors shown in the last 5 years, serious effects on the direction of microalgae R&D existed. It will detailed discussed in the “Discussion” section.
Global and Technical Distributions
Nearly 25% patents were held by United States (975) followed by Japan (541), China (289), Australia (164), Canada (155), and South Korea (119). The validated patent number was shown in Supplementary Figure 1, briefly, more than half of them are validated till the end of June, 2020.
As an intellectual property (IP) tools, it’s reasonable that most top player of patent applications were companies, such as Solazyme Inc. (now is acquired by Corbion) with 313 items and nearly 10% of the patent pool analyzed (see Supplementary Table 1). However, the Scripps Research Institute also holds 46 items and ranked first among research institutes.
To obtain an overall technical view of these patent, International Patent Classification (IPC2) information was used to classify and summarize the patents in the pool. The top related IPC classes were listed in Supplementary Table 2 and the IPC class distribution in different countries or organizations were shown in Supplementary Figure 1. The yearly distribution of major IPC was shown in Supplementary Figure 2. Briefly, the majority of patents are related to strains and their cultivation under different condition, especially some stress conditions, the introduction of some regulating reagents, the combination of different downstream treatment and bio-refinery methods or processes.
The most related class is C12N, which is directly related to microalgae itself, including compositions, propagating, preserving, or maintaining, and also including mutation or genetic engineering of microalgae as well as novel culture media. In the patent pool, 58% patents were concerned with this class. The second hot class is C12P, which relates to the processes to synthesis a desired chemical compound or composition or to separate optical isomers from a racemic mixture. It consisted with the aim of these patent to produce biofuels, which are mostly in the form of fatty acids or lipids, or carbohydrates. Among them, some multifunctional compounds, other than the feedstock to biofuels, such as special carbohydrates, pigments or medium chain fatty acids, were drawing more attentions.
After more than thousands of strains, there was no natural microalga suitable for the biofuel production directly. So in the last two decades, the artificial modification of natural strains was also concerned, especially with the development of gene engineering, such as CRISPR technology in US20160208243A1 family. So the IPC A01H reached the third rank in the second wave.
Core Techniques Within Patents for Microalgae Biofuels Based on Citation Relationships
The citation of the patent usually represented the core techniques in the field and direction of the knowledge flow (Alcácer and Gittelman, 2006). The citation in the patent is not as strict as scientific publications, however, the core techniques cannot be ignored due to their potential legal risks. In the patent pool, the citation relationship were summarized by using Cytoscape (version 3.8.0). Some important knots were significantly shown with concentrated links (Supplementary Figure 3).
The most cited validated patents, with cited number over 100, were listed in the Table 1. Among them, only US20160208243A1 was applied in 2015, and other are almost older than 10 years and close to the edge of patent term. In this 16 top cited patents, five of them were about the gene manipulation of microalgae, eight of them were about the cultivation to promote the biofuel production and three of them were concerned with the downstream bio-refinery. Bio-refinery has the advantages of high atomic economy and was expected as an integrated solution for energy, wastewater treatment, food and nutrient supply (Suganya et al., 2016). However, maybe limited by the biomass supply, except on the health-related approaches, there was few reports on the stable industrialization of bio-refinery or co-production established.
Table 1. Valid patents with more than 100 cites.
Discussion
The Driving Force for the Future Microalgae R&D Changes
As shown in Figure 1, at the beginning, the afraid of depletion of fossil fuels drove the first wave of microalgae R&D, mostly under the support of ASP by the US DOE and more likely a pure scientific affair to produce bio hydrogen or bio transportation fuels. The higher cost of microalgae cultivation and relative low oil price caused the cease of the first wave in 1995 (Sheehan et al., 1998). But, the accumulation on strains and numerous technologies helps the form of the second wave while the crude oil price dramatically increased in the early of 21 century.
The stress condition cultivation became the sign of the second wave, mostly started by Illman et al.’s (2000) work on the low nitrogen cultivation for high calorific value biomass to develop renewable energy resource. Differed to the first wave, with the increase of oil price, the microalgae biofuel R&D became a move by both scientists and venture capitals (VCs), which was marked by the launch of the beta test of CO2 and NOx emission reduction system by Greenfuel in MIT in 2004. Following Chisti and Hu et al.’s direction in 2007–08 (Chisti, 2007; Hu et al., 2008), around the stressed cultivation of microalgae, a large amount patents were applied and covered the whole processes of microalgae biofuel production. The driving force of this period was still the high crude oil price.
Things changed from 2012, when commercial shale gas realized and Tesla Model S electric car came into the market, which caused the energy production and consuming structure reformed. With less progress in the cut of production cost or significant increase in production efficiency, the VCs and big companies turned their focus. Without enough support, the patent application decrease rapidly.
After 2015, although the oil price increased a little bit, the popularization of electric car and the development of other renewable energy resources caused the traditional driving force of microalgae R&D lost.
New Driving Force From Synthetic Biology and Customized Natural Products Production
The development of biotechnology brings the hope to meet the next wave of microalgae R&D. Due to its fast growth, unicellular form, high photosynthesis capacity and diverse secondary metabolisms, the microalgae based CO2 and NOx capture will be a new driving force for the innovation of a new gene manipulation, cell or organelle factory building, non-meat protein production, medium length chain fatty acids synthesis. And above targets also consisted with the major technical classes, including C12N15, C12P7, and C12N1.
Author Contributions
DL and XC collected and manually classified the patents and drafted the manuscript. WD organized and guided the analysis. WF analyzed the collected patents and drafted the manuscript. All authors contributed to the article and approved the submitted version.
Funding
This work was supported by the DMTO grant (DMTO201409) from Dalian Institute of Chemical Physics, Chinese Academy of Sciences, Dalian Key Laboratory of Energy Biotechnology and NSFC grant (21878285) from National Natural Science Foundation of China.
Conflict of Interest
The authors declare that the research was conducted in the absence of any commercial or financial relationships that could be construed as a potential conflict of interest.
Acknowledgments
We thank Dr. Xue Song from Dalian University of Technology for her comments and suggestion on microalgae biotechnology development.
Supplementary Material
The Supplementary Material for this article can be found online at: https://www.frontiersin.org/articles/10.3389/fbioe.2020.01035/full#supplementary-material
Footnotes
- ^ https://www.macrotrends.net/1369/crude-oil-price-history-chart
- ^ https://www.wipo.int/classifications/ipc/en/
References
Alcácer, J., and Gittelman, M. (2006). Patent citations as a measure of knowledge flows: the influence of examiner citations. Rev. Econ. Stat. 88, 774–779. doi: 10.1162/rest.88.4.774
Chen, H., Wang, J., Zheng, Y., Zhan, J., He, C., and Wang, Q. (2018). Algal biofuel production coupled bioremediation of biomass power plant wastes based on Chlorella sp. C2 cultivation. Appl. Energy 211, 296–305. doi: 10.1016/j.apenergy.2017.11.058
Chisti, Y. (2007). Biodiesel from microalgae. Biotechnol. Adv. 25, 294–306. doi: 10.1016/j.biotechadv.2007.02.001
Hu, Q., Sommerfeld, M., Jarvis, E., Ghirardi, M., Posewitz, M., Seibert, M., et al. (2008). Microalgal triacylglycerols as feedstocks for biofuel production: perspectives and advances. Plant J. 54, 621–639. doi: 10.1111/j.1365-313x.2008.03492.x
Illman, A. M., Scragg, A. H., and Shales, S. W. (2000). Increase in Chlorella strains calorific values when grown in low nitrogen medium. Enzyme Microb. Technol. 27, 631–635. doi: 10.1016/s0141-0229(00)00266-0
Khan, M. I., Shin, J. H., and Kim, J. D. (2018). The promising future of microalgae: current status, challenges, and optimization of a sustainable and renewable industry for biofuels, feed, and other products. Microb. Cell. Fact. 17:36. doi: 10.1186/s12934-018-0879-x
Mata, T. M., Martins, A. A., and Caetano, N. S. (2010). Microalgae for biodiesel production and other applications: a review. Renew. Sust. Energ. Rev. 14, 217–232. doi: 10.1016/j.rser.2009.07.020
Sheehan, J., Dunahay, T., Benemann, J., and Roessler, P. (1998). Look Back at the U.S. Department of Energy’s Aquatic Species Program: Biodiesel from Algae; Close-Out Report. Golden, CO: National Renewable Energy Lab, doi: 10.2172/15003040
Shuba, E. S., and Kifle, D. (2018). Microalgae to biofuels: ‘Promising’ alternative and renewable energy, review. Renew. Sust. Energ. Rev. 81, 743–755. doi: 10.1016/j.rser.2017.08.042
Suganya, T., Varman, M., Masjuki, H. H., and Renganathan, S. (2016). Macroalgae and microalgae as a potential source for commercial applications along with biofuels production: a biorefinery approach. Renew. Sust. Energ. Rev. 55, 909–941. doi: 10.1016/j.rser.2015.11.026
Keywords: microalgae, patent, industrialization, stress cultivation, biofuel
Citation: Li D, Du W, Fu W and Cao X (2020) A Quick Look Back at the Microalgal Biofuel Patents: Rise and Fall. Front. Bioeng. Biotechnol. 8:1035. doi: 10.3389/fbioe.2020.01035
Received: 21 July 2020; Accepted: 10 August 2020;
Published: 26 August 2020.
Edited by:
Chengwei Liang, Qingdao University of Science and Technology, ChinaReviewed by:
Xinqing Zhao, Shanghai Jiao Tong University, ChinaQiang Wang, Institute of Hydrobiology (CAS), China
Copyright © 2020 Li, Du, Fu and Cao. This is an open-access article distributed under the terms of the Creative Commons Attribution License (CC BY). The use, distribution or reproduction in other forums is permitted, provided the original author(s) and the copyright owner(s) are credited and that the original publication in this journal is cited, in accordance with accepted academic practice. No use, distribution or reproduction is permitted which does not comply with these terms.
*Correspondence: Wantao Fu, ZnV3YW50YW9AZGxvdS5lZHUuY24=; Xupeng Cao, Y194X3BAZGljcC5hYy5jbg==